文章基本信息

标题：Transmission of Major and Minor Serum Proteins during Microfiltration of Skim Milk: Effects of Pore Diameters, Concentration Factors and Processing Stages
本地全文：下载
作者：Zhibin Li ; Dasong Liu ; Shu Xu 等
期刊名称：Foods
电子版ISSN：2304-8158
出版年度：2021
卷号：10
期号：4
页码：888
DOI：10.3390/foods10040888
出版社：MDPI Publishing
摘要：Effects of pore diameters (100, 50, and 20 nm), concentration factors (1–8) and processing stages (1–5) on the transmission of major serum proteins (β-lactoglobulin and α-lactalbumin) and minor serum proteins (immunoglobulin (Ig) G, IgA, IgM, lactoferrin (LF), lactoperoxidase (LPO), xanthine oxidase (XO)) during ceramic microfiltration (MF) of skim milk were studied. Holstein skim milk was microfiltered at a temperature of 50 °C, a transmembrane pressure of 110 kPa and a crossflow velocity of 6.7 m/s, using a tubular single stainless steel module that consisted of three ceramic tubes, each with 19 channels (3.5 mm inner diameter) and a length of 0.5 m. For MF with 100 nm and 50 nm pore diameters, the recovery yield of major serum proteins in permeate was 44.3% and 44.1%, while the recovery yield of minor serum proteins was slightly less by 0%–8% than 50 nm MF. MF with 20 nm pore diameters showed a markedly lower (by 12%–45%) recovery yield for both major and minor serum proteins, corresponding with its lower membrane flux. Flux sharply decreased with an increasing concentration factor (CF) up to four, and thereafter remained almost unchanged. Compared to the decrease (88%) of flux, the transmission of major and minor serum proteins was decreased by 4%–15% from CF = one to CF = eight. With increasing processing stages, the flux gradually increased, and the recovery yield of both major and minor proteins in the permeate gradually decreased and reached a considerably low value at stage five. After four stages of MF with 100 nm pore diameter and a CF of four for each stage, the cumulative recovery yield of major serum proteins, IgG, IgA, IgM, LF, LPO, and XO reached 95.7%, 90.8%, 68.5%, 34.1%, 15.3%, 39.1% and 81.2% respectively.
关键词：microfiltration; serum proteins; bioactive proteins; membrane pore diameter; concentration factor; processing stage microfiltration ; serum proteins ; bioactive proteins ; membrane pore diameter ; concentration factor ; processing stage